write ACCIDENT PREVENTION RECOMMENDATIONS for each case
Ssult89
ElectrHaz_8FatalFacts.pdf
ACCIDENT SUMMARY No. 11 Accident Type: Electrocution
Weather Conditions: Wet Ground Type of Operation: Remodeling Size of Work Crew: 2
Collective Bargaining No Competent Safety Monitor on Site: Yes
Safety and Health Program in Effect: No Was the Worksite Inspected Regularly: Yes
Training and Education Provided: No Employee Job Title: Carpenter
Age & Sex: 33-Male Experience at this Type of Work: 30 Days
Time on Project: 3 Days
BRIEF DESCRIPTION OF ACCIDENT Two employees were installing aluminum siding on a farmhouse when it became necessary to remove a 36- foot high metal pole CB antenna. One employee stood on a metal pick board between two ladders and unfastened the antenna at the top of the house. The other employee, who was standing on the ground, took the antenna to lay it down in the yard. The antenna made electrical contact with a 7200-volt power transmission tine 30 feet 10 inches from the house and 23 feet 9 inches above the ground. The employee handling the antenna received a fatal shock and the other employee a minor shock. INSPECTION RESULTS Following its investigation, OSHA issued one citation for two alleged serious violations of its construction standards. Had these standards been adhered to, the fatality might have been prevented. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 17
Accident Type: Electrocution Weather Conditions: Sunny, Clear Type of Operation: Steel Erection Size of Work Crew: 3
Collective Bargaining No Competent Safety Monitor on Site: Yes - Victim
Safety and Health Program in Effect: No Was the Worksite Inspected Regularly: Yes
Training and Education Provided: No Employee Job Title: Steel Erector Foreman
Age & Sex: 43-Male Experience at this Type of Work: 4 months
Time on Project: 4 Hours BRIEF DESCRIPTION OF ACCIDENT Employees were moving a steel canopy structure using a "boom crane" truck. The boom cable made contact with a 7200 volt electrical power distribution line electrocuting the operator of the crane; he was the foreman at the site. INSPECTION RESULTS
As a result of its investigation. OSHA issued citations for four serious violations of its construction standards dealing with training, protective equipment, and working too close to power lines. OSHA's construction safety standards include several requirements which, If they had been followed here. might have prevented this fatality. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 28
Accident Type: Electrocution Weather Conditions: Clear Type of Operation: Power Line Work Size of Work Crew: 2
Collective Bargaining Yes Competent Safety Monitor on Site: Yes
Safety and Health Program in Effect: No Was the Worksite Inspected Regularly: No
Training and Education Provided: No Employee Job Title: Lineman
Age & Sex: 44-Male Experience at this Type of Work: 11 Months
Time on Project: 6 Weeks
BRIEF DESCRIPTION OF ACCIDENT A lineman was electrocuted while working on grounded de-energized lines. He was working from a defective basket on an articulated boom aerial lift when the basket contacted energized lines which ran beneath the de-energized lines. The defective basket permitted current to pass through a drain hole cut into the body of the basket, then through the employee, and to ground via the de-energized line. INSPECTION RESULTS OSHA cited the company for two serious violations and one other than serious violation of its construction standards. Had barriers been erected to prevent contact with adjacent energized lines, the electrical shock might have been prevented. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 30
Accident Type: Electrocution Weather Conditions: Raining Type of Operation: Electrical Contractor Size of Work Crew: 2
Collective Bargaining No Competent Safety Monitor on Site: Yes
Safety and Health Program in Effect: Inadequate Was the Worksite Inspected Regularly: Yes
Training and Education Provided: No Employee Job Title: Journeyman Electrician
Age & Sex: 39-Male Experience at this Type of Work: 16 Years
Time on Project: 1 Day BRIEF DESCRIPTION OF ACCIDENT An electrician was removing metal fish tape from a hole at the base of a metal light pole. The fish tape became energized, electrocuting him. INSPECTION RESULTS As a result of its inspection, OSHA issued a citation for three serious violations of the agency's construction standards. Had requirements for de-energizing energy sources been followed, the electrocution might have been prevented. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 40 Accident Type: Electrocution
Weather Conditions: Sunny/Clear Type of Operation: Fence Construction Size of Work Crew: 5
Collective Bargaining No Competent Safety Monitor on Site: No
Safety and Health Program in Effect: Yes Was the Worksite Inspected Regularly: No
Training and Education Provided: No Employee Job Title: Laborer
Age & Sex: 25-Male Experience at this Type of Work: 3 Months
Time on Project: 1 Day
BRIEF DESCRIPTION OF ACCIDENT
Five employees were constructing a chain link fence in front of a house and directly below a 7200-volt energized power line. They were installing 21-foot sections of metal top rail on the fence. One employee picked up a 21-foot section of top rail and held it up vertically. The top rail contacted the 7200-volt line, and the employee was electrocuted.
INSPECTION RESULTS
Following its inspection, OSHA determined that the employee who was killed had never received any safety training from his employer nor any specific instruction in avoiding the hazards posed by overhead power lines. The agency issued two serious citations for the training deficiencies.
ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 49
Accident Type: Electrical Shock Weather Conditions: Clear/Hot Type of Operation: Masonry Contractor Size of Work Crew: 6
Collective Bargaining No Competent Safety Monitor on Site: No
Safety and Health Program in Effect: Inadequate Was the Worksite Inspected Regularly: Yes
Training and Education Provided: No Employee Job Title: Cement Finisher
Age & Sex: 34-Male Experience at this Type of Work: 10 Years
Time on Project: 1 Day BRIEF DESCRIPTION OF ACCIDENT Two employees were spreading concrete as it was being delivered by 1 concrete pumper truck boom. The truck was parked across the street from the worksite. Overhead power lines ran perpendicular to the boom on the pumper truck. One employee was moving the hose (elephant trunk) to pour the concrete when the boom of the pumper truck came in contact with the overhead rover line carrying 7,620 volts. Employee received a fatal electric shock and fell on the other employee who was assisting him. The second employee received massive electrical shock and burns. * Safety training requirement was not being carried out at time of accident. INSPECTION RESULTS OSHA cited the employer for not instructing each employee to recognize and avoid unsafe conditions which apply to the work and work areas. Employer was also cited for operating equipment within ten feet of an energized electrical, ungrounded transmission lines rated 50 kV or less and not erecting insulating barriers. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 57 Accident Type: Electrocution
Weather Conditions: Clear/Hot/Humid Type of Operation: Window Shutter Installers Size of Work Crew: 2
Collective Bargaining N/A Competent Safety Monitor on Site: No
Safety and Health Program in Effect: Partial Was the Worksite Inspected Regularly: No
Training and Education Provided: Some Employee Job Title: Helper
Age & Sex: 17-Male Experience at this Type of Work: One Month
Time on Project: One Month BRIEF DESCRIPTION OF ACCIDENT One employee was climbing a metal ladder to hand an electric drill to the journeyman installer on a scaffold about five feet above him. When the victim reached the third rung from the bottom of the ladder he received an electric shock that killed him. The investigation revealed that the extension cord had a missing grounding prong and that a conductor on the green grounding wire was making intermittent contact with the energizing black wire thereby energizing the entire length of the grounding wire and the drill's frame. The drill was not double insulated. INSPECTION RESULTS As a result of its investigation, OSHA issued citations for violations of construction standards. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The Fatal Facts were selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed. Current as of: 11/01/2001.
ACCIDENT SUMMARY No. 60
Accident Type: Electrocution Weather Conditions: Indoor Work
Type of Operation: Installing and
Trouble-shooting overhead lamps
Size of Work Crew: 15 Competent Safety Monitor on Site: Yes
Safety and Health Program in Effect: Inadequate Was the Worksite Inspected Regularly: Yes
Training and Education Provided: No Employee Job Title: Electrician
Age & Sex: 53-Male Experience at this Type of Work: Journeyman
Time on Project: 1 Month BRIEF DESCRIPTION OF ACCIDENT The employee was attempting to correct an electrical problem involving two non-operational lamps. He proceeded to the area where he thought the problem was. He had not shut off the power at the circuit breaker panel nor had he tested the wires to see if they were live. He was electrocuted when he grabbed the two live wires with his left hand and then fell from the ladder. INSPECTION RESULTS As a result of its investigation, OSHA Issued citations alleging three serious violations. OSHA's construction standards include several requirements which, if they had been followed here, might have prevented this fatality. ACCIDENT PREVENTION RECOMMENDATIONS ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ ______________________________________________________________________________________ NOTE: The case here described was selected as being representative of fatalities caused by improper work practices. No special emphasis or priority is implied nor is the case necessarily a recent occurrence. The legal aspects of the incident have been resolved, and the case is now closed.
